The Influence of Operating Temperature on Mass Transfer Characteristics during a Diffusion Process in Bilimbi Fruit

Authors

  • Waigoon RITTIRUT School of Agricultural Technology, Walailak University, Nakhon Si Thammarat 80161
  • Chairat SIRIPATANA School of Engineering and Resource, Walailak University, Nakhon Si Thammarat 80161

Keywords:

Averrhoa bilimbi, bilimbi fruit, temperature effect, shrinkage, osmotic dehydration, diffusion rates, volume change, diffusivity

Abstract

The effects of operating temperature on an osmotic sucrose solution with a selected concentration pattern (30-50-70 °Brix) on mass transfer characteristics during the diffusion process in bilimbi fruits in a dehydration system were investigated. Half-ripe bilimbi fruits were used. In the pretreatment step, all fruits were blanched in boiling water for 1 min to soften the fruit for better diffusion. The osmotic solutions were prepared without agitation. For each temperature level, bilimbi fruits were firstly immersed in a 30 °Brix sucrose solution for 3,000 min, then a 50 °Brix for 3,000 min, and finally a 70 °Brix for 3,000 min. The ratio of solution to raw materials was 2:1 and the pH was adjusted to 3.5 before each step. Samples from both solid and liquid phases were taken out at different periods in order to determine water loss, soluble solid gain, acid loss, corresponding diffusivities, as well as shrinkage. It was found that an operating temperature of 40 °C yielded the lowest mass transfer characteristics i.e. water loss and its rate, soluble solid gain and its rate, and acid loss and its rate while there was nearly no difference in the values obtained at 50 and 60 °C. Nevertheless, at the highest concentration and at all temperatures, though the water loss (%) and the acid loss (%) still increased upon time the soluble solid gain (%) decreased. The phenomenon was similar to what happened in mechanical squeezing. This result corresponded to continuous shrinking, which was clearly observed during dehydration. For bilimbi fruits, the final shrinkage was found to be 80 % of the initial volume. The final shrinkage value and also the rate of shrinkage for each period were lowest at 40 °C with no difference at 50 and 60 °C. Higher concentrations like 50 and 70 °Brix did not lead to a higher rate of water loss, soluble solid gain and acid loss; on the contrary it lowered these values. In addition, for all experiments, the diffusivity for each component i.e. water, soluble solids, and acid decreased as the concentration was increased (30-50-70 °Brix). Seemingly for blanched materials at higher concentrations, strong interactions among components were observed. The results lead to a conclusion that blanched materials in a system without agitation were accompanied by shrinkage, by a squeezing-like phenomenon. The concentration effect not only dominated the temperature effect but also stabilized the rate of mass transfer especially at the operating temperatures of 50 and 60 °C.

Downloads

Download data is not yet available.

Metrics

Metrics Loading ...

References

F Kaymak-Ertekin and M Sultanogle. Modeling of mass transfer during osmotic dehydration of apples. J. Food Eng. 2000; 46, 243-50.

TRA Magee, AA Hassaballah and WR Murphy. Internal mass transfer during osmotic dehydration of apples slices in sugar solutions. Int. J. Food Sci. Tech. 1983; 1, 177-8.

CI Beristain, E. Azuara, R Cortes and HS Garcia. Mass transfer during osmotic dehydration of pineapples rings. Int. J. Food Sci. Tech. 1990; 25, 576-82.

A Lenart and PP Lewicki. Osmotic Dehydration of Carrots at High Temperature. In: WEL Spiess and H Schubert (eds.). Engineering and Food Preservation Processes and Related Techniques, volume II. Elsevier, London, 1990, p. 731-40.

NK Rastogi and KSMS Raghavarao. Effect of temperature and concentration on osmotic dehydration of coconut. Lebensm. Wiss. Technol. 1996; 29, 669-72.

NE Mavroudis, V Gekas and V Sjöholm. Osmotic dehydration of apples - effects of agitation and raw material characteristics. J. Food Eng. 1998; 35, 191-209.

MR Khoyi and J Hesari. Osmotic dehydration kinetics of apricot using sucrose solution. J. Food Eng. 2007; 78, 1355-60.

SK Sharma, SJ Mulvaney and SSH Rizvi. Food Process Engineering-Theory and Laboratory Experiments, John Wiley and Sons, New York, 2000, p. 225-35.

F Abas, NH Lajis, DA Israf, S Khozirah and YU Kalsom. Antioxidant and nitric oxide inhibition activities of selected Malay traditional vegetables. Food Chem. 2006; 95, 566-73.

PP Sutar and DK Gupta. Mathematical modeling of mass transfer in osmotic dehydration of onion slices. J. Food Eng. 2007; 78, 90-7.

BKH Tan, CH Tan and PN Pushparaj. Anti-diabetic activity of the semi-purified fractions of Averrhoa bilimbi in high fat diet fed-streptozotocin-induced diabetic rats. Life Sci. 2005; 76, 2827-39.

H Ali, PJ Houghton and A Soumyanath. -Amylase inhibitory activity of some Malaysian plants used to treat diabetes; with particular reference to Phyllanthus amarus. J. Ethnopharmacol. 2006; 107, 449-55.

N Peter. Pushparaj. National University of Singapore. Averrhoa bilimbi fractions possess anti-diabetic activity. Fitness & Wellness Business Week. Atlanta: Jun 22, 2005. p. 38.

Bilimbi-Averrhoa Bilimbi, Available at: http://www.hort.purdue.edu/newcrop/ morton/bilimbi.html, accessed June 2006.

W Rittirut and C Siripatana. Osmotic dehydration of bilimbi fruit (Averrhoa bilimbi). In: Proceedings of the International Conference on Agricultural, Food, and Biological Engineering & Post Harvest/Production Technology. TSAE & ASABE, Khon Kaen, Thailand. 2007, p. 1-31.

NE Mavroudis, V Gekas and I Sjöholm. Osmotic dehydration of apples. Shrinkage phenomena and the significance of initial structure on mass transfer rates. J. Food Eng. 1998; 38, 101-23

A Monsalve-Gonzalez, GV Barbosa-Canovas and RP Cavalieri. Mass transfer and textural changes during processing of apples by combined methods. J. Food Sci. 1993; 8, 1118-24.

P Yuthachit. 1999. The Development of Process for Mango Glace Production, Master of Science Thesis in Food Technology (in Thai). Prince of Songkla University, Songkla, Thailand.

C Siripatana. Solute diffusion in fruit, vegetable and cereal processing I: Simplified solutions for diffusion in anomalous shapes. Songklanakarin J. Sci. Technol. 1997; 19, 77-88.

NK Rastogi, KSMS Raghavarao and K Niranjan. Mass transfer during osmotic dehydration of banana: Fickian diffusion in cylindrical configuration. J. Food Eng. 1997; 31, 423-32.

HN Lazarides, V Gekas and N Mavroudis. Apparent mass diffusivity in fruit and vegetable tissues undergoing osmotic processing. J. Food Eng. 1997; 31, 315-24.

V Gekas, R Oste and I Lamberg. Diffusion in heated potato tissue. J. Food Sci. 1993; 58, 827-31.

F Tufvesson. 1995. Preheating effects on potassium leakage from potato tissue with emphasis on cellular level understanding. Diploma thesis. Food Engineering Department, Lund, Sweden.

J Wenz, V Gekas and W Crapiste. Cellular deterioration of processed fruits and vegetables. In: Proceedings of the 1st Ibero-American Congress of Food Engineering, Campinas, Brazil. 1995, p. 315-24.

A Chiralt and P Talens. Physical and chemical changes induced by osmotic dehydration in plant tissues. J. Food Eng. 2005; 67, 167-77.

J Hawkes and JM Flink. Osmotic concentration of fruit slices prior to freeze dehydration. J. Food Proc. Preserv. 1978; 2, 265-84.

T Thummadetsak 1993. Mass Transfer in Pineapple Juice Extractor, Master of Engineering Thesis in Chemical Engineering (in Thai). Prince of Songkla University, Songkla, Thailand.

HN Lazarides and NE Mavroudis. Kinetics of osmotic dehydration of a highly shrinking vegetable tissue in a salt-free medium. J. Food Eng. 1996; 30, 61-74.

ACC Rodrigues, RL Cunha and MD Hubinger. Rheological properties and colour evaluation of papaya during osmotic dehydration processing. J. Food Eng. 2003; 59, 129-35.

N Mauseng, M Wunsin and W Khaokaew. 2003 The Investigation on Diffusion Mechanism for the Infusion Process of Garcinia Fruits, Special project (in Thai). Division of Food Technology, School of Agricultural Technology. Walailak University, Nakhon Si Thammarat, Thailand.

W Rittirut and C Siripatana. Drying characteristics of Garcinia atroviridis. Walailak J. Sci. & Tech. 2006; 3, 13-32.

Luikov. The Theory of Heat Diffusion. Academic Press, New York, 1969, p. 685

G Panades, P Fito, Y Aguiar, MN de Villavicencio and V Acosta. Osmotic dehydration of guava: Influence of operating parameters on process kinetics. J. Food Eng. 2006; 72, 383-9.

HN Lazarides, V Gekas and NE Mavroudis. Apparent mass diffusivities in fruit and vegetable tissues undergoing osmotic processing. J. Food Eng. 1997; 31, 315-24.

M Ferrando and WLE Spiess. Cellular response of plant tissue during the osmotic treatment with sucrose, maltose, and trehalose solutions. J. Food Eng. 2001; 49, 115-27.

Downloads

Published

2011-11-08

How to Cite

RITTIRUT, W., & SIRIPATANA, C. (2011). The Influence of Operating Temperature on Mass Transfer Characteristics during a Diffusion Process in Bilimbi Fruit. Walailak Journal of Science and Technology (WJST), 6(1), 59–78. Retrieved from https://wjst.wu.ac.th/index.php/wjst/article/view/73

Issue

Section

Research Article

Most read articles by the same author(s)